[摘要]新疆勾机出租公司如何精心保养你的挖掘机。发动机：The 1 engine:机油、机油滤芯绝对要用正厂件，按规定保养周期更换。旧机更需细心呵护，机油机滤更换时间可酌情缩短，以使发动机寿命更长。
公司如何精心保养你的挖掘机。1.发动机：The 1 engine:机油、机油滤芯绝对要用正厂件，按规定保养周期更换。旧机更需细心呵护，机油机滤更换时间可酌情缩短，以使发动机寿命更长。
Oil, oil filter must be used are plant parts, according to the provisions of the maintenance cycle change. The old machine more need careful care, engine oil and filter replacement time can be shortened, so that the engine life.
柴油尽量使用正规加油站提供的，即使正规加油站加的柴油，也不要直接加入油箱，加入前先过滤（比较常用的办法是在加油口套袜子）。每天开工前在柴油箱底部及油水分离器处放水。柴油滤芯买正厂件，按规定保养周期更换柴油滤芯。（澄清一点，正厂滤芯滤纸细密，杂质拦截量大，因此较易堵塞，比副厂滤芯更换周期短，所以不是长期不堵的滤芯是好滤芯）
Diesel oil as far as possible the use of regular gas station provides regular gas station, even with diesel, also do not directly into the tank, add before filtering (more commonly used way is in the gas mouth socks). The day before the start of the water in the diesel oil tank bottom and oil-water separator. Diesel filter to buy are plant parts, according to the provisions of the maintenance cycle to replace diesel filter. (a point of clarification, the plant is fine filter core filter, impurities interception amount is large, it is easy to plug, than vice factory filter replacement cycle is short, so not long blocking filter is a good filter)
空气滤芯经常检查，外滤芯灰多时用压缩空气从内向外吹，气压不可过大防止把滤芯吹破。内滤不可清洗。外滤清洗2、3次后与内滤同时更换新的。不可为了节油而长期使用怠速工作，防止积碳。
Air filter regularly check, external filter dust for a long time with compressed air blowing from the inside to the outside, the pressure is not too large to prevent the core blowing broken. The inner filter can not be cleaned. External filtration cleaning 2, 3 times and inner filter and the replacement of the new. Not to save fuel and long-term use of idle work, prevent carbon deposition.
2.液压：
2 hydraulic:
按规定保养周期更换液压油、回油滤芯、先导滤芯，并注意滤芯上有没有吸附铁屑、铜屑。使用破碎器时，液压油劣化变质加速，更换周期应缩短。不可长期缺油工作。更换液压油或液压部件后，注意排出空气。
According to the provisions of the maintenance cycle, replacing the hydraulic oil back to the oil filter, the pilot filter, and note that there is no adsorption filter on iron, copper scrap. The use of the crusher, hydraulic oil deterioration accelerated, the replacement cycle should be shortened. Not long lack of oil. Replacement of hydraulic oil and hydraulic components, pay attention to exhaust air.
3.电气：
3 electrical:
注意防水，不要涉深水作业，做清洁时不要用水直接冲洗电器件。不要在电瓶箱内堆放杂物，尤其是金属工具等，易引发火灾。不要用铁丝铜丝代替保险，也不要用不合规格的保险替换。挖掘机长期停放时要拆卸电瓶线防止馈电。
Pay attention to the waterproof, not in deep water operation, do not wash clean water directly electrical parts. Do not put their things in the battery box, especially metal tools, easy to cause a fire. Do not replace the insurance with wire copper wire, also do not use substandard insurance replacement. Remove the battery line to prevent feed excavator long park.
4.机械：
4 mechanical:
回转减速器，行走减速器按周期更换齿轮油。销轴部分注意清理泥土杂物，加注黄油。涉水作业，水漫过回转齿圈时，注意更换回转齿圈内黄油。注意油缸杆防锈。挖掘机长期停放时将裸露金属部分涂抹黄油防锈。
The rotary gear reducer, reducer gear changing oil according to cycle. The part of the pin shaft pay attention to clean up mud debris, add butter. Wading operation, water diffuse through the slewing ring, pay attention to replace the slewing ring in butter. Note the cylinder rod rust. Excavator Long Park will be exposed metal part butter rust.
5.结构：
5 structure:
每天检查销轴螺栓有无松动、脱落、缺失，并及时紧固。每天检查结构有无开裂、变形。停放挖掘机时注意周围环境，停放在坚实平稳硬质地面，不要停在河边，悬崖边，山坡下，防止意外出险。停放时铲斗油缸完全收回，铲斗落地，防止油缸被撞。
Every day to check the pin bolt has no loose, missing, and timely fastening. Check every day there is no cracking, deformation structure. Park excavator when attention to the surrounding environment, park in the solid smooth hard ground, don't stop at the riverside, the edge of the cliff, hillside, to prevent accidental loss. Park when the bucket cylinder fully recovered, bucket floor, to prevent the cylinder was.
与就找新疆信合工程机械租赁，我们以效益为中心，秉承诚信做人、踏实做事的优良传统，以体制创新为平台，走专业化、合作化的经营道路，谋求企业经济效益和社会效益的双重最大化。